60 Watt Guitar Amplifier


Posted on Feb 6, 2014

This design adopts a well established circuit topology for the power amplifier, using a single-rail supply of about 60V and capacitor-coupling for the speaker(s). The advantages for a guitar amplifier are the very simple circuitry, even for comparatively high power outputs, and a certain built-in degree of loudspeaker protection, due to capacitor


60 Watt Guitar Amplifier
Click here to download the full size of the above Circuit.

C8, preventing the voltage supply to be conveyed into loudspeakers in case of output transistors` failure. The preamp is powered by the same 60V rails as the power amplifier, allowing to implement a two-transistors gain-block capable of delivering about 20V RMS output. This provides a very high input overload capability. The Darlington transistor types listed could be too oversized for such a design. You can substitute them with MJ11014 (Q3) and MJ11013 (Q4) or TIP142 (Q3) and TIP147 (Q4). D1 and D2 can be any Schottky-barrier diode types. With these devices, the harmonic modifier operation will be hard. Using for D1 and D2 two common 1N4148 silicon diodes, the harmonic modifier operation will be softer. In all cases where Darlington transistors are used as the output devices it is essential that the sensing transistor (Q2) should be in as close thermal contact with the output transistors as possible. Therefore a TO126-case transistor type was chosen for easy bolting on the heatsink, very close to the output pair. R9 must be trimmed in order to measure about half the voltage supply across the positive lead of C7 and ground. A better setting can be done using an oscilloscope, in order to obtain a symmetrical clipping of the output wave form at maximum output power.




Leave Comment

characters left:

Related Circuits

  • New Circuits

    .

     


    Popular Circuits

    PIC16F84A Gas Detector
    Ham Band Vfo Circuit
    pic16f688 based digital voltmeter
    Research and Development
    Channel Imbalance in DAC
    Digital Radar Speedometer
    DIY/Homemade Radiation Geiger Dosimeter
    Arduino Thermostat
    Multimeter AC voltage measuring circuit



    Top