A Friendly Charger Schematic for Mobile Phones


Posted on Feb 5, 2014

Most mobile chargers do not have current/voltage regulation or short-circuit protection. These chargers provide raw 6-12V DC for charging the battery pack. Most of the mobile phone battery packs have a rating of 3. 6V, 650mAh. For increasing the life of the battery, slow charging at low current is advisable. Six to ten hours of charging at 150-200m


A Friendly Charger Schematic for Mobile Phones
Click here to download the full size of the above Circuit.

A current is a suitable option. This will prevent heating up of the battery and extend its life. The circuit described here, provides around 180mA current at 5. 6V and protects the mobile phone from unexpected voltage fluctuations that develop on the mains line. So the charger can be left on` over night to replenish the battery charge. The circuit protects the mobile phone as well as the charger by immediately disconnecting the output when it senses a voltage surge or a short circuit in the battery pack or connector. It can be called a middle man` between the existing charger and the mobile phone. It has features like voltage and current regulation, over-current protection, and high- and low-voltage cut-off. An added specialty of the circuit is that it incorporates a short delay of ten seconds to switch on when mains resumes following a power failure. This protects the mobile phone from instant voltage spikes. When short-circuit occurs at the battery terminal, resistor R8 senses the over-current, allowing Q1 to conduct and light up D1. Glowing of D2 indicates the charging mode, while D1 indicates short-circuit or over-current status. The value of resistor R8 is important to get the desired current level to operate the cut-off. With the given value of R8 (3. 3 ohms), it is 350 mA. Charging current can also be changed by increasing or decreasing the value of R7 using the I=V/R` rule. Construct the circuit on a common PCB and...




Leave Comment

characters left:

Related Circuits

  • New Circuits

    .

     


    Popular Circuits

    1 Khz Inductance Meter ATTINY861
    Monostable photocell circuit
    60W-225-400mhz-amplifier
    Low-Cost Window Comparator
    Battery Test Circuit Circuit
    Subwoofer Filter Circuit Using Op-Amp TL072
    230 Volt AC To Inverter SwitchingCircuit
    FM Wireless HI-FI circuit
    Tesla coil project and other high voltage projects
    PC computer based frequency meter circuit diagram
    Preamplifier and Bandpass filter for SDR
    Analog IO Protection
    GH-75 type circuit hydrogen atom welder
    AC contactor silent operation of the circuit



    Top